Peugeot Expert recalls
Recalls to 31 Oct 2026, from DVSA's file. Each recall shows its own launch date.
DVSA lists 83 safety recalls naming the Peugeot Expert, launched from 1998 to 2026. Most recalls cover only cars built in certain dates or chassis number ranges, so check a specific car on GOV.UK's recall check.
Peugeot Expert recalls at a glance
- Recalls
- 83
- 1998 to 2026
- Latest recall
- 16 March 2026
- R/2026/109
Source: DVSA RecallsFile.csv, recalls launched from 1992 to October 2026, downloaded 31 October 2026. Open Government Licence v3.0.
Every Peugeot Expert recall
Newest first. The concern is the part or system affected, the defect is what can go wrong, and the remedy is what the manufacturer does to put it right.
Water Pump Pulley
R/2026/109, launched 16 March 2026. Also covers the Partner, Rifter
Defect: On affected vehicles due to a production nonconformity the water pump may malfunction which may cause a loss of engine power and result in the engine shutting down.
Remedy: Replace the water pump.
Peugeot Cross carline Fuel Injection common rail.
R/2026/020, launched 21 January 2026. Also covers the 308, Partner, Rifter
Defect: On affected vehicles a non-conformity issue with the fuel injection common rail may lead to a loosening of the nut and a potential fuel leak.
Remedy: Check the fuel injection common rail and if necessary replace the rail and high-pressure fuel pipes.
Peugeot Traveller/Expert (K0)Rifter/Partner (K9) IVI s/w via OTA update.
R/2026/008, launched 19 December 2025. Also covers the Partner, Rifter, Traveller
Defect: Affected vehicle may face a black screen on the Instrument Panel Cluster with several functions not available to view.
Remedy: Update the In-Vehicle-Infotainment software via Over-the-Air.
Peugeot Expert Traveller (K0) Low In-use performance ratio – ECM software
R/2025/499, launched 12 November 2025. Also covers the Traveller
Defect: On affected vehicles there is an issue with the Engine Control Module (ECM) calibration which may lead to non-compliance with regulatory emission requirements.
Remedy: Update the ECM calibration.
Peugeot Traveller/Expert4- Rear Brake Discs.
R/2025/413, launched 29 September 2025. Also covers the Traveller
Defect: Affected vehicles may have been equipped with rear brake discs out of specification. These brake discs have insufficient contact with the wheel hub resulting in abnormal stress concentration.
Remedy: Check the rear brake discs and replace them and the brake pads if necessary.
Emission recall – On Board Diagnostics
R/2025/344, launched 18 August 2025. Also covers the 2008, 208, 3008, 308, 5008, 508, Boxer, Partner, Rifter, Traveller
Defect: Vehicles may be affected by incorrect performance of the On-Board-Diagnostics related to Selective Catalytic Reduction system and/or Diesel Particle Filter. The Malfunction Indicator Light (MIL) may not illuminate in the event of a malfunction and therefore does not comply with emission regulations.
Remedy: Update the Engine Control Unit software to ensure compliance to regulations.
Peugeot Expert (K0) Lower Control Arm Bushing
R/2025/310, launched 1 August 2025, 12,293 vehicles affected across the models it covers
Defect: On affected vehicles the bolts on the front wishbone may break due to corrosion.
Remedy: Replace the bolts and bushings on both sides of the front wishbone.
Traction Battery software
R/2025/120, launched 24 March 2025. Also covers the 2008, 208, Partner, Rifter, Traveller
Defect: Affected vehicles may face an error in the Battery Monitoring Unit software.
Remedy: Update the Battery Monitoring Unit software.
Peugeot Expert K0 TBMU software
R/2024/467, launched 20 November 2024, 158 vehicles affected across the models it covers
Defect: On affected vehicles they may have been supplied with incorrect software in the Traction Battery Management Unit TBMU that can lead to a non-compliance with regulatory requirements.
Remedy: On the affected vehicles the TBMU software will be updated to meet regulatory requirements.
Peugeot Traveller/Expert K0 Seat Fixation
R/2024/456, launched 4 November 2024. Also covers the Traveller
Defect: On affected vehicles there may be insufficient fixing on the 1st and/or 2nd row of seats that could potentially allow seat movement in the event of a collision
Remedy: On the affected vehicles seat fixings will be reworked
Peugeot Expert (K0) Display Screws missing.
R/2024/419, launched 23 October 2024, 1,966 vehicles affected across the models it covers
Defect: On affected vehicles the radio display fixing screws may be missing allowing a potential detachment of the display during a collision.
Remedy: On the affected vehicles the fixings will be checked and fitted if necessary.
Peugeot Expert (K0) Rear Springs
R/2024/314, launched 5 August 2024, 993 vehicles affected across the models it covers
Defect: Affected vehicles may have been equipped with the incorrect rear springs which can result in impaired driving behaviour when fully loaded or a risk of rear spring detachment in a worst-case scenario when empty.
Remedy: Replace both rear springs.
Peugeot Expert – Ground Connections
R/2024/216, launched 7 May 2024, 10 vehicles affected across the models it covers
Defect: On affected vehicles there could be a loss of ground connections for some electrical harnesses which could result in a worst-case scenario in the loss of several vehicle functions with safety impacts and a risk of erratic behaviour of the vehicle.
Remedy: Check and re-tighten the ground connections.
On affected vehicles the AC compressor stator wiring could develop a fault leading to current loss inside the AC compressor that could result in a vehicle powertrain shutdown when driving.
R/2023/140, launched 9 May 2023, 29,537 vehicles affected across the models it covers. Also covers the 2008, 208, Partner, Rifter, Traveller
Defect: On affected vehicles the AC compressor stator wiring could develop a fault leading to current loss inside the AC compressor that could result in a vehicle powertrain shutdown when driving.
Remedy: Reprogram the Powertrain Diagnosis ECU with updated software.
Affected vehicles may have a steering tie rod/track rod end nut that has not been tightened to the correct torque.
R/2023/079, launched 23 March 2023, 4 vehicles affected across the models it covers. Also covers the Traveller
Defect: Affected vehicles may have a steering tie rod/track rod end nut that has not been tightened to the correct torque.
Remedy: Replace the steering tie rod/track rod end nut and tighten to the correct torque.
The fuel line could make contact with the body and lead to fuel leakage
R/2022/338, launched 1 December 2022, 2,231 vehicles affected across the models it covers. Also covers the Traveller
Defect: Some vehicles may have been equipped with an incorrectly positioned fuel pipe.
Remedy: Check fuel pipe positioning correct if necessary and fit protective sleeve.
THE EFFICIENCY OF HANDBRAKE AND SERVICE BRAKE MIGHT BE COMPROMISED
R/2022/241, launched 8 August 2022, 57 vehicles affected across the models it covers. Also covers the Traveller
Defect: On the affected vehicles equipped with a manual handbrake the efficiency of the handbrake and service brake may be compromised.
Remedy: Check the rear brake caliper references and replace as necessary.
THE HIGH VOLTAGE HARNESS FITTED MIGHT NOT BE TO THE CORRECT SPECIFICATION
R/2022/203, launched 13 July 2022, 16 vehicles affected across the models it covers. Also covers the 2008, 208, Traveller
Defect: The High Voltage Harness might not be to the correct specification.
Remedy: Check the harness conformity and replace it if necessary
HEADRESTS ON THE FRONT MODULAR SEAT DO NOT CONFORM TO THE DESIGN SPECIFICATION
R/2022/127, launched 10 May 2022, 708 vehicles affected across the models it covers. Also covers the Traveller
Defect: Affected vehicles may have been equipped with headrests on the front modular seat which do not conform to the design specification.
Remedy: Check the conformity of the front headrests (presence of the catch); in cases of non-conformity the front headrests will be replaced.
ELECTRICAL HARNESS COULD MOVE FROM ORIGINAL POSITION AND WEAKEN THE HARNESS
R/2022/029, launched 31 January 2022, 51 vehicles affected across the models it covers. Also covers the Traveller
Defect: The rear window electrical harness could become displaced from its original position and present a potential thermal issue.
Remedy: Check the routing of harness and replace the electrical harness if necessary. Add a fastening clip to ensure that the electrical harness will be maintained in its normal position.
THE REAR SPRING CENTRALISER MIGHT BE WELDED INCORRECTLY
R/2021/262, launched 8 July 2021, 2 vehicles affected across the models it covers. Also covers the Traveller
Defect: The rear spring centraliser might be welded incorrectly.
Remedy: Add 3 weld spots to the rear spring centralisers
VEHICLES AFFECTED MAY HAVE A SINGLE WHEEL BOLT ON BOTH LEFT HAND SIDE WHEELS WHICH MAY NOT HAVE BEEN TIGHTENED CORRECTLY
R/2021/004, launched 5 January 2021, 11 vehicles affected across the models it covers. Also covers the Traveller
Defect: A single wheel bolt on both left-hand wheels may not be tightened to the correct tightening torque.
Remedy: Check and if necessary replace wheel bolts and any other associated parts if consequential damage has occurred.
VEHICLES AFFECTED MAY HAVE A SINGLE WHEEL BOLT ON BOTH RIGHT HAND SIDE WHEELS WHICH MAY NOT HAVE BEEN TIGHTENED CORRECTLY
R/2021/003, launched 5 January 2021, 4 vehicles affected across the models it covers. Also covers the Traveller
Defect: A single wheel bolt on both right-hand wheels may not be tightened to the correct tightening torque.
Remedy: Check and if necessary replace wheel bolts and any other associated parts if consequential damage has occurred.
A REAR SEAT LONGITUDINAL ADJUSTMENT LEVER MAY NOT LOCK PROPERLY
R/2020/309, launched 28 October 2020, 11 vehicles affected across the models it covers. Also covers the Traveller
Defect: A rear seat longitudinal adjustment lever may not lock properly.
Remedy: Check affected seat frames and replacing them if necessary.
THE REAR BRAKE HOSE MAY BECOME DAMAGED OVER TIME DUE TO MOVEMENT BETWEEN THE HOSE AND HOLDING CLIP
R/2020/092, launched 27 March 2020, 4 vehicles affected across the models it covers. Also covers the Traveller
Defect: There is a possibility that the rear brake hose may become damaged due to relative movement between the hose and the holding clip.
Remedy: Check the condition of the left and right rear brake hoses and replace them if necessary.
TIGHTENING OF REAR SUSPENSION FIXINGS MAY NOT BE TO SPECIFICATION
R/2020/078, launched 27 March 2020, 1 vehicle affected across the models it covers. Also covers the Traveller
Defect: The tightening of some rear suspension fixings may not be correct to specification.
Remedy: Correcting some tightening torques and replacing some nuts and bolts.
POSSIBLE NON CONFORMITY OF SEALS IN FRONT WHEEL ARCHES COULD LEAD TO WATER INGRESS INTO CERTAIN ELECTRONIC UNITS
R/2020/070, launched 27 March 2020, 916 vehicles affected across the models it covers. Also covers the Traveller
Defect: Possible non-conformity of certain seals in the front wheel arches could lead to water ingress into the passenger compartment.
Remedy: Resealing these areas checking for the presence of water in the passenger compartment and replacing certain components in the interior if required.
ONE OR MORE FIXATIONS OF THE SEATBELTS LOWER BOLTS MAY NOT BE TIGHTENED CORRECTLY
R/2019/438, launched 27 March 2020, 4,485 vehicles affected across the models it covers. Also covers the Traveller
Defect: The tightening and positioning of the seat belt lower bolts may be incorrect.
Remedy: This campaign consists of checking and if necessary correcting both the position of the bolt and the tightening torque of all of the lower fixings of the seat belts.
ONE OR MORE FIXATIONS OF THE SEATBELTS AND ONE GROUND CABLE MAY NOT BE TIGHTENED CORRECTLY
R/2019/435, launched 27 March 2020, 127 vehicles affected across the models it covers. Also covers the Traveller
Defect: The tightening of the seat belt fixings and of certain earth cables may not conform to specification
Remedy: Tightening of the seat belt fixings and of certain earth cables.
NON-CONFORMITY OF THE REAR BRAKE CALIPERS
R/2019/433, launched 27 March 2020, 134 vehicles affected across the models it covers. Also covers the Traveller
Defect: A non-conformity of the rear brake callipers could reduce the efficiency of the parking brake.
Remedy: Check and if necessary replace the callipers
FUEL TUBES UNDER BODY MAY BECOME DAMAGED OVER TIME
R/2019/431, launched 27 March 2020, 22,882 vehicles affected across the models it covers. Also covers the Traveller
Defect: The fuel pipes under the body may have been damaged over time due to a relative movement between these pipes and their surroundings.
Remedy: Check the condition of the fuel pipes and replacing them if necessary. New protection will be fitted on all vehicles to prevent this damage in the future.
THE REAR BRAKE HOSES MAY HAVE BEEN DAMAGED DUE TO MOVEMENT BETWEEN THESE HOSES AND A CLIP
R/2019/425, launched 27 March 2020, 21,217 vehicles affected across the models it covers. Also covers the Traveller
Defect: The rear brake hoses may have been damaged over time due to inappropriate movement between these hoses and a clip.
Remedy: Check the condition of the rear left-hand and right-hand brake hoses and replacing them if necessary. A new retaining clip is fitted on all vehicles to prevent this relative movement.
CERTAIN SEALS IN THE FRONT WHEEL ARCHES MAY NOT BE CORRECT TO SPECIFICATION
R/2019/429, launched 5 February 2020, 3 vehicles affected across the models it covers. Also covers the Traveller
Defect: Certain seals in the front wheel arches may not be correct to specification and may cause water ingress into the passenger compartment
Remedy: Resealing these areas checking for the presence of water in the passenger compartment and replacing certain components in the interior if required
ON THE AFFECTED VEHICLES IT IS POSSIBLE THAT A CRACK COULD DEVELOP OVER TIME ON THE COUNTERWEIGHT SUPPORTS LOCATED UNDER THE REAR FLOOR
R/2019/294, launched 2 September 2019, 777 vehicles affected across the models it covers
Defect: Counterweight could become detached and fall from the vehicle
Remedy: Add two new fixings for each counterweight
IF THE FRONT CENTRE PASSENGER SEATING POSITION IS OCCUPIED THE FRONT OUTER PASSENGER SEAT BELT COULD RELEASE
R/2019/258, launched 15 August 2019, 16,828 vehicles affected across the models it covers. Also covers the Traveller
Defect: There is a risk of inadvertent release to the front outer passenger seat belt.
Remedy: Modifying the central seat buckle with foam and heat-shrinkable protective tubing
THE FRONT SUSPENSION MAY NOT BE CORRECT TO SPECIFICATION
R/2019/146, launched 9 May 2019, 10,936 vehicles affected across the models it covers. Also covers the Traveller
Defect: Possible slackening of the front wishbone ball joint.
Remedy: Increasing the tightening torque of the ball joint and adding thread lock if the ball joint threads are found to be rusty or loose the ball joint will be replaced
THE STEERING RACK ASSEMBLY MAY NOT BE CORRECT TO SPECIFICATION
R/2019/034, launched 1 February 2019, 14 vehicles affected across the models it covers. Also covers the Traveller
Defect: The steering rack assembly may not be correct to specification.
Remedy: Replace the steering rack assembly and the fixings.
THE FIXING BOLT OF THE FRONT SUSPENSION WISHBONE MAY NOT BE CORRECT TO SPECIFICATION
R/2019/032, launched 1 February 2019, 21 vehicles affected across the models it covers. Also covers the Traveller
Defect: The fixing bolt of the front Suspension wishbone may not be correct to specification.
Remedy: Replace the fixing bolts and nuts of the front suspension wishbones.
THE REAR SUSPENSION WISHBONE MOUNTING BOLTS MAY NOT BE CORRECT TO SPECIFICATION
R/2019/030, launched 1 February 2019, 326 vehicles affected across the models it covers. Also covers the Traveller
Defect: The rear suspension wishbone mountings bolts may not be correct to specification.
Remedy: Replacement of the rear suspension wishbone bolts.
UNDER CERTAIN DRIVING CONDITIONS THE AIR CONDITIONING COMPRESSOR PULLEY COULD BREAK
R/2019/028, launched 1 February 2019, 2,643 vehicles affected across the models it covers. Also covers the Traveller
Defect: The air conditioning compressor pulley could break and damage other components.
Remedy: Replace the air conditioning compressor pulley and if necessary the protective cover.
EXCESSIVE LOADING OF FRONT SUSPENSION COULD RESULT IN THE LOOSENING OF THE FRONT WISHBONE LOWER BALL JOINTS
R/2019/026, launched 1 February 2019, 2,942 vehicles affected across the models it covers. Also covers the Traveller
Defect: Excessive loading of the front suspension could result in the loosening of the front wishbone lower ball joints.
Remedy: Increasing the tightening torque of the ball joint and adding thread lock to the ball joint threads if the ball joint threads are found to be rusty the ball joint will be replaced.
Tow ball support bracket durability inadequate
R/2018/196, launched 25 July 2018, 96 vehicles affected across the models it covers
Defect: The tow ball bracket could not withstand mechanical constraints when subjected to the highest stress levels which can occur during the vehicle's lifetime.
Remedy: The manufacturer’s remedy involves the replacement of the tow ball support bracket with a redesigned version.
COOLING SYSTEM STRATEGY COULD OVERHEAT THE ENGINE.
R/2018/192, launched 24 July 2018, 841 vehicles affected across the models it covers. Also covers the Traveller
Defect: The cooling system strategy and the maximum temperature alert could cause the engine to overheat this may cause an oil leak from the sump drain cap. Due to the incorrect operation of the warning system there is no driver alert.
Remedy: The remedy involves downloading new engine management software.
Engine oil gallery sealing plug incorrectly tightened
R/2018/185, launched 19 July 2018, 47 vehicles affected across the models it covers. Also covers the 3008, 308, 5008, Boxer, Traveller
Defect: On the affected vehicles the tightening of a sealing plug on the engine oil gallery may not be correct to specification.This could lead over time to an oil leak which in rare cases could result in oil leaking on to the road.
Remedy: The remedy consists of tightening the engine oil gallery sealing plug to the correct torque
ENGINE COMPONENT MAY NOT BE TO SPECIFICATION
R/2018/003, launched 3 January 2018, 314 vehicles affected across the models it covers. Also covers the Traveller
Defect: An engine component may not be to specification which could result in loss of engine performance. This may lead to the engine stalling and potentially causing an engine failure. In very unlikely circumstances the vehicle speed may increase without warning but will stop on its own after a few seconds.
Remedy: On affected vehicles carry out a functional diagnostic check of the engine. If necessary replace the engine.
STARTER MOTOR SUPPLY WIRING HARNESS MAY BECOME DAMAGED
R/2017/265, launched 14 September 2017, 16 vehicles affected across the models it covers. Also covers the Traveller
Defect: The positioning of the starter supply terminal may be incorrect. This may allow it to foul other components and cause a short circuit.
Remedy: On affected vehicles check the positioning of the terminal and correct it if necessary.
STARTER RELAY MAY OVERHEAT
R/2017/222, launched 18 July 2017, 84 vehicles affected across the models it covers. Also covers the Traveller
Defect: Possible non-compliance of an internal component of the starter control relay could cause damage by overheating. This could cause unintended operation of the starter motor and in extreme instances; there is a risk of fire.
Remedy: On affected vehicles check and if necessary replace the relay
AIR CONDITIONING COMPRESSOR SUPPORT MOUNTINGS MAY NOT BE TO SPECIFICATION
R/2017/184, launched 19 June 2017, 1,326 vehicles affected across the models it covers. Also covers the Traveller
Defect: The tightness of one of the air conditioning compressor support mountings may not be correct to specification. This will result in an abnormal noise and possibility of the compressor becoming insecure
Remedy: On affected vehicles check the tightness of the support; where necessary the support will be replaced.
STARTER MOTOR MAY NOT OPERATE CORRECTLY
R/2017/140, launched 24 April 2017, 6,768 vehicles affected across the models it covers. Also covers the 2008, 208, 3008, 308, 508, Traveller
Defect: A possible nonconformity of an internal component of the starter motor relay could affect the control of the starter motor. This could adversely affect the starting operation and damage the starter motor due to overheating and in extreme cases there is a risk of fire.
Remedy: On affected vehicles check and where necessary replace the starter motor relay.
GEARBOX ACTUATOR AY NOT BE TO SPECTIFICATION
R/2017/125, launched 7 April 2017, 13 vehicles affected across the models it covers. Also covers the 2008, 208, 508, Partner, Traveller
Defect: A component in the gearbox actuator may not be to the correct specification which may affect gear selection.
Remedy: On affected vehicles replace the gearbox actuator
REDUCTION IN BRAKING EFFORT DUE TO AIR IN THE SERVO
R/2017/074, launched 22 February 2017, 5 vehicles affected across the models it covers. Also covers the Traveller
Defect: The tightening torque of one of the nuts of the connection between the brake servo unit and the brake pedal may be not correct to specification. This may allow air to enter the servo
Remedy: Check servo security and where necessary replace the brake servo unit
STEERING BOLTS MAY BE TIGHTENED INCORRECTLY
R/2017/072, launched 22 February 2017, 2 vehicles affected across the models it covers. Also covers the Traveller
Defect: Incorrect assembly of the steering rack which could cause the loss of the mechanical link between the steering pinion valve and the steering rack during parking manoeuvres at full lock.
Remedy: Check affected vehicles and where necessary replace the steering rack.
UNEXPECTED AIRBAG DEPLOYMENT
R/2017/068, launched 22 February 2017, 100 vehicles affected across the models it covers. Also covers the Traveller
Defect: It has been identified that due to a possible non-conformity of certain seals on the vehicle’s body there is the possibility that water can enter the passenger compartment of the vehicle. The occupants should experience either wet carpets and or a possible damp smell. However the ingress of water into the cabin could affect the electrical operation of the airbag module which could lead to an unexpected deployment of the airbag.
Remedy: Recall all affected vehicles to add additional sealant to the body interfaces and if required to replace any interior components damaged by the water ingress.
WHEEL MAY DETACH
R/2017/064, launched 22 February 2017, 42 vehicles affected across the models it covers. Also covers the Traveller
Defect: It has been identified that the wheel bolts may not have been tightened to the correct specification. The driver may experience a vibration through the steering wheel. However it not rectified there is a risk that the wheels may become damaged over time or the wheel could in extreme cases could detach from the vehicle whilst driving. This could cause loss of control of the vehicle.
Remedy: Recall all affected vehicles to check the tightness of the road wheel bolts and rectify as necessary. In certain cases the replacement of the bolt(s) and wheel(s) may be necessary.
FUEL MAY LEAK AROUND FUEL FILLER NECK
R/2017/062, launched 22 February 2017, 58 vehicles affected across the models it covers. Also covers the Traveller
Defect: It has been identified that the fuel filler neck assembly may not have been correctly installed at production. This can therefore result in a fuel leak from around the fuel filler area if the fuel tank is filled to maxumum or can fuel leak if the vehicle rolls over..
Remedy: Recall all affected vehicles to check fuel filler neck and rework/rectify if required.
UNEXPECTED AIRBAG DEPLOYMENT
R/2017/061, launched 22 February 2017, 1,312 vehicles affected across the models it covers. Also covers the Traveller
Defect: On the affected vehicles a possible nonconformity of certain seals on the vehicle’s body could lead to water ingress in the passenger compartment. This may affect the operation of the passenger air bag. Unintended deployment is possible.
Remedy: On affected vehicles add extra sealant and replace wet or water damaged components.
REDUCTION IN BRAKING EFFORT DUE TO AIR IN THE SERVO
R/2017/059, launched 22 February 2017, 2 vehicles affected across the models it covers. Also covers the Traveller
Defect: The bolts retaining the front shock absorber could come loose. This may adversely affect the steering control of the vehicle.
Remedy: On affected vehicles replace the front shock absorber retaining bolts.
AIRBAG MAY INCORRECTLY DEPLOY
R/2016/172, launched 20 July 2016, 797 vehicles affected across the models it covers. Also covers the Partner
Defect: On affected vehicles the driver's air bag inflation device may not conform to specification. As a result may not deploy correctly during an impact.
Remedy: Replace the driver's air bag module on affected vehicles
FUEL MAY LEAK
R/2015/241, launched 9 December 2015, 12,833 vehicles affected across the models it covers. Also covers the 3008, 308, 5008, 508, 807, RCZ
Defect: The fuel heating device integrated in to the diesel fuel filter cover may be defective and allow heat to build up within the electrical supply connector causing the cover to distort and air to enter the fuel circuit. This could make the vehicles difficult to start and a warning light will be illuminated on the dash board. The engine could be difficult or not possible to start. In the worst cases a diesel fuel leak could eventually appear.
Remedy: Recall the vehicles that are likely to be affected and replace the fuel heater cover. Additionally the electrical connector will be inspected and where necessary replaced.
FUEL MAY LEAK
R/2014/161, launched 1 December 2014, 2,713 vehicles affected across the models it covers
Defect: On affected vehicles; Under certain conditions the fuel leak off pipe may become insecure at the connection to the injector. If this happens fuel may leak form the connection. Fuel may accumulate in the engine compartment and vehicle users will be aware of a smell of fuel.
Remedy: Inspect connection on affected vehicles and where necessary replace the fuel leak off return pipe fixing with new adhesive.
BRAKING EFFICIENCY MAY BE AFFECTED
R/2014/003, launched 21 January 2014, 54 vehicles affected across the models it covers
Defect: On certain vehicles the front brake discs may not be the required thickness for the vehicle definition. This concern may result in reduced braking efficiency.
Remedy: Recall the vehicles that are likely to be affected to check and where necessary replace the front brake discs.
WIPER MOTOR MAY FAIL
R/2014/002, launched 21 January 2014, 446 vehicles affected across the models it covers
Defect: An internal fault with the wiper motor could cause it to stop working. In some rare cases the windscreen wipers may stop working while in operation.
Remedy: Recall affected vehicles and check the manufacturing date of the wiper motor and add a supplementary earth wiring harness if necessary.
POTENTIAL FOR REDUCED STEERING CONTROL
R/2013/096, launched 31 August 2013, 71 vehicles affected across the models it covers. Also covers the 807
Defect: The steering column link bolt which retains the steering wheel to the steering column may not have been tighten to the correct specification. This can result in a gradual increase in movement between the steering wheel and shaft with an associated rattle. This should identify the issue to the driver however if the driver does not heed this warning then the steering control of the vehicle could be reduced.
Remedy: Recall all affected vehicles to check and if required re-torque the steering column link bolt.
TYRE MAY DEFLATE
R/2012/041, launched 28 April 2012, 14 vehicles affected across the models it covers. Also covers the 807
Defect: Some tyres may have suffered superficial damage when the vehicle was being transported. The front Left hand tyre may have localised damage on the tread or the inner side. The tyre may rip and deflate.
Remedy: Carry out a visual check of the condition of the tyre in the affected areas and replace the tyre if necessary.
OIL MAY LEAK
R/2011/141, launched 21 October 2011, 4 vehicles affected across the models it covers
Defect: In rare cases on the concerned engines a possible manufacturing nonconformity of the cylinder head may lead to an oil leak.
Remedy: Check and replace cylinder head.
POWER STEERING ASSISTANCE MAY FAIL.
R/2011/083, launched 11 July 2011, 1,577 vehicles affected across the models it covers. Also covers the 807
Defect: It is possible that the wiring harness for the power assisted steering motor may come in contact with other components in the engine bay. Should this occur then it is possible that the power steering assistance on this large vehicle may become affected.
Remedy: Recall affected vehicles and fit protection to the wiring harness.
FUEL MAY LEAK
R/2011/017, launched 22 February 2011, 2,834 vehicles affected across the models it covers. Also covers the 3008, 308, 5008, RCZ
Defect: On some 2.0 l HDI vehicles potential contact between the fuel return pipe and the diesel filter support may eventually cause the pipe to become worn through friction.
Remedy: The manufacturer has requested that some protection be added to the pipe to ensure its long-term resistance to wear.
BRAKING ASSISTANCE MAY NOT PERFORM CORRECTLY
R/2010/222, launched 16 December 2010, 24,220 vehicles affected across the models it covers. Also covers the 307, 308, 407, 607, 807
Defect: In very rare circumstances the vacuum pump one way valve may not function correctly which could affect the level of braking assistance.
Remedy: Recall the vehicles that are likely to be affected to replace the brake vacuum pump one way valve.
LIGHTS MAY FAIL WITHOUT WARNING.
R/2010/157, launched 6 October 2010, 2,903 vehicles affected across the models it covers. Also covers the 307, 308, 807
Defect: It has been identified that the position of the exterior lighting control ring may not be detected by the lighting management system and the lights may switch off without warning.
Remedy: Recalled vehicles will have the lighting management software updated.
BRAKING EFFICIENCY MAY BE COMPROMISED
R/2010/114, launched 10 August 2010, 386 vehicles affected across the models it covers. Also covers the 807
Defect: The threaded portion of the brake linkage rod in the brake control system may not be to conformity. This could result in a reduction of braking efficiency.
Remedy: Recall affected vehicles to check rod and replace if found not to meet conformity.
BRAKING PERFORMANCE MAY BE AFFECTED
R/2010/029, launched 16 March 2010, 2,001 vehicles affected across the models it covers
Defect: It has been identified that water may ingress the brake drums causing premature brake lining wear. Should this occur the brake effort produced by the rear wheels may be reduced.
Remedy: Recalled vehicles will have a seal fitted to the handbrake cable and the subject brake linings replaced.
FUEL MAY LEAK
R/2010/016, launched 15 February 2010, 2,611 vehicles affected across the models it covers
Defect: It has been identified that the possibility exists that contact between the fuel return pipe and the engine shield may take place inside the engine compartment. Should this occur wear on the pipe would ensue which in the worst case; would result in a fuel leak.
Remedy: Recalled vehicles will be fitted with an additional fastener to ensure that contact is not made and if necessary the fuel return pipe will be replaced.
LIGHTS MAY SWITCH OFF UNEXPECTEDLY
R/2009/104, launched 16 October 2009, 48,938 vehicles affected across the models it covers. Also covers the 307
Defect: In rare cases the lighting management system may incorrectly detect the lighting switch ring position which may cause the lights to cut out.
Remedy: Recall affected vehicles and download new version of vehicle exterior lighting software
ACCELERATOR PEDAL MAY NOT RETURN WHEN RELEASED
R/2008/183, launched 19 December 2008, 290 vehicles affected across the models it covers
Defect: The throttle pedal may not return to its initial position as a result of a nonconformity to specification.
Remedy: Recall the vehicles that are likely to be affected to check and where necessary replace the pedal mechanism.
REDUCED BRAKING PERFORMANCE
R/2008/015, launched 1 February 2008, 19,867 vehicles affected across the models it covers. Also covers the 307, 407, 607, 807
Defect: It has been identified that on the specified vehicles a fault may develop with the brake vacuum pump. This can result in hardening of the brake pedal with an attendant loss of braking efficiency.
Remedy: Recalled vehicles will have the vacuum pump replaced.
POTENTIAL LOSS OF POWER STEERING ASSISTANCE
R/2007/148, launched 25 October 2007, 749 vehicles affected across the models it covers
Defect: It has been identified that the earthing terminal for the electrical power assisted steering assembly may require reinforcing. This is necessary in order to provide the correct electrical supply to the power steering assembly and to prevent possible loss of steering assistance. In any case the vehicle's steering capacity is not altered.
Remedy: Recalled vehicles will have the power steering earth connection reinforced as necessary.
SEAT BELT BRACING ACTION MAY BE AFFECTED
R/2006/064, launched 11 April 2006, 37 vehicles affected across the models it covers. Also covers the 807
Defect: The seat belt locking action may not be as fast as it is designed to be.
Remedy: Recall the vehicles that may be affected to check the date of manufacture of the seat belts and where necessary replace the seat belts.
ENGINE SUPPORT YOKE WELD MAY FAIL.
R/2003/130, launched 31 July 2003, 201 vehicles affected across the models it covers
Defect: There is a possibility that the lower engine mounting point is weak. This may lead to significant engine vibration which in turn could result in the right hand drive shaft coming adrift.
Remedy: Examine and replace the engine support yoke where found necessary.
POSSIBLE DAMAGE TO TYRES
R/2002/158, launched 8 November 2002, 163 vehicles affected across the models it covers
Defect: There is a risk that the tyres may have been damaged during fitting onto the wheel rim at the factory.
Remedy: Replace all five tyres.
POSSIBLE REDUCTION IN BRAKING ASSISTANCE PLUS ENGINE OPERATING PROBLEMS.
R/2002/021, launched 5 April 2002, 41,175 vehicles affected across the models it covers. Also covers the 306, 406, 806
Defect: In adverse wet weather conditions water may enter the engine management solenoid valve operating circuit. This could result in engine operating problems and a reduction in power assistance to the brake pedal if the water enters the brake vacuum circuit via the solenoid valves.
Remedy: Recall affected vehicles to examine and if necessary replace the engine management solenoid valves with ones sealed against the ingress of water.
POSSIBLE LOSS OF BRAKE FLUID
R/2001/123, launched 19 September 2001, 109 vehicles affected across the models it covers
Defect: There is a risk of internal cracking of the 4-way brake pipe unions ( non- ABS models) or the 2 x 4 - way brake pipe unions ( ABS models). This could result in a gradual loss of brake fluid and reduced braking efficiency.
Remedy: Recall affected vehicles and replace the four way brake pipe unions.
VACUUM PUMP DRIVE PIN
R/2000/149, launched 2 January 2001, 5,835 vehicles affected across the models it covers
Defect: Brake vacuum pump drive pin may fail as a result of premature wear. This could result in a loss of power assistance at the brake pedal.
Remedy: Recall affected vehicles to fit a quality assured replacement drive pin to the brake vacuum pump.
POSSIBLE INADVERTANT RELEASE OF HANDBRAKE
R/1998/111, launched 29 December 1998, 828 vehicles affected across the models it covers
Defect: It has been identified that there is a possibility of premature wear of the handbrake lever ratchet leading to potential disengagement of the handbrake.
Remedy: Recall affected vehicles and where necessary replace the original handbrake with a quality assured unit.
Source: DVSA RecallsFile.csv, recalls launched from 1992 to October 2026, downloaded 31 October 2026. Open Government Licence v3.0.
What to do next
If you own a Peugeot Expert, check its registration on GOV.UK and ask a Peugeot dealer whether any recall work is outstanding. If you are buying one, ask the seller for proof the work was done, and run a Motoring Insider history check for finance, write-offs and the MOT history.