Mercedes-Benz Sprinter MOT pass rate and common faults
MOT tests in 2025, published 22 Jun 2026. DVSA publishes a new year each summer.
24,406 Mercedes-Benz Sprinter cars had an MOT in 2025 and 71.3% passed first time. That is above what cars of the same ages scored (68.6%).
Find the year your car was first registered below, then check the faults it is most likely to fail on.
Pass rate by year
Each year's first-time pass rate, with a tick for all cars first used that year. Years with fewer than 300 tests, and cars over 20 years old, are left out. Years with 1,000 or more tests link to a page of their own, with that year's common faults.
| Item | Mercedes-Benz Sprinter | All cars that year |
|---|---|---|
| 2022 | 88.6% | 88.5% |
| 2021 | 83.6% | 87.2% |
| 2020 | 85.5% | 86.0% |
| 2019 | 83.8% | 83.5% |
| 2018 | 81.2% | 80.9% |
| 2017 | 79.9% | 78.2% |
| 2016 | 75.3% | 74.9% |
| 2015 | 74.7% | 71.9% |
| 2014 | 69.6% | 68.6% |
| 2013 | 69.7% | 65.8% |
| 2012 | 66.2% | 63.5% |
| 2011 | 66.1% | 61.2% |
| 2010 | 68.6% | 59.3% |
| 2009 | 67.7% | 58.3% |
| 2008 | 62.9% | 57.2% |
| 2007 | 64.3% | 57.4% |
| 2006 | 59.5% | 57.0% |
| 2005 | 61.1% | 57.6% |
Source: DVSA, tests in 2025, published 22 June 2026.
Common failures
The share of all Mercedes-Benz Sprinter cars tested that failed on, or had fixed at the station, each item. Worth checking before the MOT or before you buy.
| Item | Value |
|---|---|
| Service brake (roller test): efficiency below requirements | 4.8% |
| Position lamp: not working | 2.6% |
| Wipers: does not clear the windscreen effectively | 2.5% |
| Rigid brake pipes: excessively corroded | 2.2% |
| Malfunction indicator lamp: inoperative or indicates a malfunction | 1.8% |
| Ball joint: ball joint excessively worn | 1.7% |
| Service brake (roller test): efficiency less than 50% of the required value | 1.7% |
| Rear fog lamp: not working | 1.7% |
Source: DVSA, tests in 2025, published 22 June 2026.
Common advisories
Advisories are things the tester noticed that were not bad enough to fail. They often turn into failures later. What advisories mean for the next MOT.
| Item | Value |
|---|---|
| Rigid brake pipes: corroded, covered in grease or other material | 15.0% |
| Brake discs: worn, pitted or scored, but not seriously weakened | 10.7% |
| Ball joint: ball joint has slight play | 9.1% |
| Play in steering rack inner joint(s) | 8.8% |
| Tread depth: worn close to legal limit/worn on edge | 8.2% |
| Engine oil leaks: leak, but not excessive | 7.1% |
| Condition: slightly damaged/cracking or perishing | 4.2% |
| Pins and bushes: pin or bush worn but not resulting in excessive movement | 3.5% |
Source: DVSA, tests in 2025, published 22 June 2026.
Typical mileage
Recorded mileage at the MOT. A car well above the range for its age has done more work than most; one far below is worth a closer look at its MOT history.
| Age | Low | Typical | High | All cars, typical |
|---|---|---|---|---|
| 3-5 years | 23,700 | 57,500 miles | 103,100 | 30,900 |
| 6-8 years | 49,300 | 92,000 miles | 154,700 | 51,800 |
| 9-11 years | 68,800 | 114,800 miles | 168,100 | 73,500 |
| 12-14 years | 83,600 | 132,600 miles | 179,900 | 91,400 |
| 15-17 years | 80,400 | 139,400 miles | 189,100 | 101,600 |
| 18-20 years | 82,100 | 136,900 miles | 183,100 | 106,700 |
| 21+ years | 80,000 | 131,200 miles | 182,200 | 99,200 |
The middle half of cars fall between the low and high figures. Source: DVSA, tests in 2025, published 22 June 2026.
Reliability and recalls
- Mercedes-Benz Sprinter reliability score, adjusted for age and ranked against other models.
- 124 recalls for the Mercedes-Benz Sprinter, from the DVSA recalls list.
- Check if a Mercedes-Benz has been recalled on GOV.UK, using its registration.
- All Mercedes-Benz models and the Mercedes-Benz vehicle history check.
Checking one car?
These figures describe groups of cars. A vehicle history report shows the full MOT history, mileage, outstanding finance, write-offs and stolen records for one registration.
Figures from the DVSA anonymised MOT testing data for MOT tests in 2025, published by the Driver and Vehicle Standards Agency. Analysis by Motoring Insider. Contains public sector information licensed under the Open Government Licence v3.0. How we work out these figures.
Every dataset we use is listed on our data sources page, with the credit lines on our attribution page.