Toyota Hiace MOT pass rate and common faults
MOT tests in 2025, published 22 Jun 2026. DVSA publishes a new year each summer.
13,023 Toyota Hiace cars had an MOT in 2025 and 65.1% passed first time. That is above what cars of the same ages scored (60.0%).
Find the year your car was first registered below, then check the faults it is most likely to fail on.
Pass rate by year
Each year's first-time pass rate, with a tick for all cars first used that year. Years with fewer than 300 tests, and cars over 20 years old, are left out. Years with 1,000 or more tests link to a page of their own, with that year's common faults.
Common failures
The share of all Toyota Hiace cars tested that failed on, or had fixed at the station, each item. Worth checking before the MOT or before you buy.
| Item | Value |
|---|---|
| Component mounting prescribed areas: prescribed area excessively corroded significantly reducing structural strength | 6.0% |
| Position lamp: not working | 5.8% |
| Wipers: does not clear the windscreen effectively | 4.5% |
| Stop lamp: not working | 3.8% |
| Rigid brake pipes: excessively corroded | 2.4% |
| Integral vehicle structure condition: corroded to the extent that the rigidity of the assembly is significantly reduced | 2.2% |
| Registration plate lamp(s): inoperative in the case of a single lamp or all lamps | 2.2% |
| Linkage pins and bushes: pin or bush excessively worn | 2.1% |
Source: DVSA, tests in 2025, published 22 June 2026.
Common advisories
Advisories are things the tester noticed that were not bad enough to fail. They often turn into failures later. What advisories mean for the next MOT.
| Item | Value |
|---|---|
| Rigid brake pipes: corroded, covered in grease or other material | 18.1% |
| Tread depth: worn close to legal limit/worn on edge | 14.5% |
| Coil spring: corroded | 10.0% |
| Wheel bearings: has slight play | 8.8% |
| Component mounting prescribed areas: prescribed area is corroded but not considered excessive | 8.0% |
| Linkage pins and bushes: pin or bush worn but not resulting in excessive movement | 7.9% |
| Condition: slightly damaged/cracking or perishing | 7.5% |
| Engine oil leaks: leak, but not excessive | 7.5% |
Source: DVSA, tests in 2025, published 22 June 2026.
Typical mileage
Recorded mileage at the MOT. A car well above the range for its age has done more work than most; one far below is worth a closer look at its MOT history.
| Age | Low | Typical | High | All cars, typical |
|---|---|---|---|---|
| 12-14 years | 82,700 | 122,500 miles | 166,400 | 91,400 |
| 15-17 years | 100,100 | 136,400 miles | 180,800 | 101,600 |
| 18-20 years | 110,700 | 146,900 miles | 188,500 | 106,700 |
| 21+ years | 106,600 | 142,300 miles | 181,300 | 99,200 |
The middle half of cars fall between the low and high figures. Source: DVSA, tests in 2025, published 22 June 2026.
Reliability and recalls
- No reliability score yet: that needs 20,000 tests on cars aged 3 and over, and the Toyota Hiace had 13,022. Why we set the bar there.
- Check if a Toyota has been recalled on GOV.UK, using its registration.
- All Toyota models and the Toyota vehicle history check.
Checking one car?
These figures describe groups of cars. A vehicle history report shows the full MOT history, mileage, outstanding finance, write-offs and stolen records for one registration.
Figures from the DVSA anonymised MOT testing data for MOT tests in 2025, published by the Driver and Vehicle Standards Agency. Analysis by Motoring Insider. Contains public sector information licensed under the Open Government Licence v3.0. How we work out these figures.
Every dataset we use is listed on our data sources page, with the credit lines on our attribution page.