Toyota Hilux MOT pass rate and common faults
MOT tests in 2025, published 22 Jun 2026. DVSA publishes a new year each summer.
75,304 Toyota Hilux cars had an MOT in 2025 and 69.9% passed first time. That is below what cars of the same ages scored (73.9%).
Find the year your car was first registered below, then check the faults it is most likely to fail on.
Pass rate by year
Each year's first-time pass rate, with a tick for all cars first used that year. Years with fewer than 300 tests, and cars over 20 years old, are left out. Years with 1,000 or more tests link to a page of their own, with that year's common faults.
| Item | Toyota Hilux | All cars that year |
|---|---|---|
| 2022 | 85.1% | 88.5% |
| 2021 | 82.6% | 87.2% |
| 2020 | 80.2% | 86.0% |
| 2019 | 79.2% | 83.5% |
| 2018 | 76.3% | 80.9% |
| 2017 | 75.2% | 78.2% |
| 2016 | 69.4% | 74.9% |
| 2015 | 65.0% | 71.9% |
| 2014 | 63.2% | 68.6% |
| 2013 | 60.3% | 65.8% |
| 2012 | 59.1% | 63.5% |
| 2011 | 57.5% | 61.2% |
| 2010 | 57.0% | 59.3% |
| 2009 | 58.1% | 58.3% |
| 2008 | 56.8% | 57.2% |
| 2007 | 59.0% | 57.4% |
| 2006 | 58.9% | 57.0% |
| 2005 | 59.1% | 57.6% |
Source: DVSA, tests in 2025, published 22 June 2026.
Common failures
The share of all Toyota Hilux cars tested that failed on, or had fixed at the station, each item. Worth checking before the MOT or before you buy.
| Item | Value |
|---|---|
| Position lamp: not working | 3.7% |
| Wipers: does not clear the windscreen effectively | 3.1% |
| Service brake (roller test): efficiency below requirements | 2.7% |
| Coil spring: fractured or broken | 2.3% |
| Rear fog lamp: not working | 2.3% |
| Registration plate lamp(s): inoperative in the case of a single lamp or all lamps | 2.2% |
| Stop lamp: not working | 1.9% |
| Brake pads: less than 1.5 mm thick | 1.8% |
Source: DVSA, tests in 2025, published 22 June 2026.
Common advisories
Advisories are things the tester noticed that were not bad enough to fail. They often turn into failures later. What advisories mean for the next MOT.
| Item | Value |
|---|---|
| Tread depth: worn close to legal limit/worn on edge | 11.8% |
| Rigid brake pipes: corroded, covered in grease or other material | 8.5% |
| Brake pads: wearing thin | 6.9% |
| Chassis condition: is corroded but structural rigidity is not significantly reduced | 5.1% |
| Engine oil leaks: leak, but not excessive | 3.6% |
| Shock absorbers: has light misting of oil | 3.5% |
| Condition: slightly damaged/cracking or perishing | 3.4% |
| Brake discs: worn, pitted or scored, but not seriously weakened | 3.2% |
Source: DVSA, tests in 2025, published 22 June 2026.
Typical mileage
Recorded mileage at the MOT. A car well above the range for its age has done more work than most; one far below is worth a closer look at its MOT history.
| Age | Low | Typical | High | All cars, typical |
|---|---|---|---|---|
| 3-5 years | 30,000 | 45,400 miles | 65,900 | 30,900 |
| 6-8 years | 53,500 | 75,600 miles | 103,200 | 51,800 |
| 9-11 years | 70,100 | 94,800 miles | 124,400 | 73,500 |
| 12-14 years | 86,300 | 113,300 miles | 144,500 | 91,400 |
| 15-17 years | 102,900 | 133,300 miles | 167,800 | 101,600 |
| 18-20 years | 111,600 | 143,600 miles | 180,200 | 106,700 |
| 21+ years | 114,600 | 150,500 miles | 191,000 | 99,200 |
The middle half of cars fall between the low and high figures. Source: DVSA, tests in 2025, published 22 June 2026.
Reliability and recalls
- Toyota Hilux reliability score, adjusted for age and ranked against other models.
- 3 recalls for the Toyota Hilux, from the DVSA recalls list.
- Check if a Toyota has been recalled on GOV.UK, using its registration.
- All Toyota models and the Toyota vehicle history check.
Checking one car?
These figures describe groups of cars. A vehicle history report shows the full MOT history, mileage, outstanding finance, write-offs and stolen records for one registration.
Figures from the DVSA anonymised MOT testing data for MOT tests in 2025, published by the Driver and Vehicle Standards Agency. Analysis by Motoring Insider. Contains public sector information licensed under the Open Government Licence v3.0. How we work out these figures.
Every dataset we use is listed on our data sources page, with the credit lines on our attribution page.